ZEP ANTIBACTERIAL HAND SOAP
Version: 1.2
Revision Date: 04/24/2020
Print Date: 07/15/2020
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION | |
Material name | ZEP ANTIBACTERIAL HAND SOAP |
Material number | R46101 |
Manufacturer or supplier's details | |
Company | Zep Inc.
|
Address | 350 Joe Frank Harris Parkway, SE Emerson, GA 30137
|
Telephone | 404-352-1680 |
Emergency telephone numbers | |
For SDS Information | Compliance Services 1-877-428-9937 |
For a Medical Emergency | 877-541-2016 Toll Free - All Calls Recorded |
For a Transportation | CHEMTREC: 800-424-9300 - All Calls Recorded. |
Emergency | In the District of Columbia 202-483-7616 |
SECTION 2. HAZARDS IDENTIFICATION | |
Emergency Overview | |
Appearance | viscous liquid |
Colour | clear, red, orange |
Odour | No data available |
GHS Classification | |
Eye irritation | Category 2A |
GHS label elements | |
Hazard pictograms | |
Signal word | Warning
|
Hazard statements | H319 Causes serious eye irritation.
|
Precautionary statements | Prevention: P264 Wash skin thoroughly after handling. P280 Wear eye protection/ face protection. Response: P305 + P351 + P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P337 + P313 If eye irritation persists: Get medical advice/attention |
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | ||
Substance / Mixture | Mixture | |
Hazardous components | ||
Chemical name | CAS-No. | Concentration [%] |
glycerol | 56-81-5 | >= 1 - < 3 |
cetrimonium chloride | 112-02-7 | >= 1 - < 3 |
Fatty acids, C8-18 and C18-unsatd., compds. with diisopropanolamine | 68855-69-6 | >= 1 - < 3 |
N-[3-(dimethylamino)propyl]dodecanamide Noxide | 61792-31-2 | >= 1 - < 3 |
The exact percentages of disclosed substances are withheld as trade secrets. |
SECTION 4. FIRST AID MEASURES | |
General advice | Move out of dangerous area. Show this safety data sheet to the doctor in attendance. Do not leave the victim unattended. |
If inhaled | If unconscious, place in recovery position and seek medical advice. If symptoms persist, call a physician. |
In case of skin contact | This product is formulated for use on skin but should always be immediately washed off with plenty of water. Discontinue use if irritation and redness develop. If conditions persist for more than 72 hours, consult a physician. |
In case of eye contact | Remove contact lenses. Protect unharmed eye. Keep eye wide open while rinsing. If eye irritation persists, consult a specialist. If in eyes, rinse with water for 15 minutes. |
If swallowed | Keep respiratory tract clear. Never give anything by mouth to an unconscious person. DO NOT induce vomiting unless directed to do so by a physician or poison control center. If symptoms persist, call a physician. |
Most important symptoms and effects, both acute and delayed | Effects are immediate and delayed. Symptoms may include irritation, redness, pain, and rash. Causes serious eye irritation. Review section 2 of SDS to see all potential hazards. |
Notes to physician | Treat symptomatically. Symptoms may be delayed. |
SECTION 5. FIREFIGHTING MEASURES | |
---|---|
Suitable extinguishing media | Dry chemical Foam Alcohol-resistant foam Carbon dioxide (CO2)
|
Unsuitable extinguishing media
| High volume water jet
|
Specific hazards during firefighting | Do not allow run-off from fire fighting to enter drains or water courses.
|
Hazardous combustion products | Carbon dioxide (CO2) Carbon monoxide Smoke Nitrogen oxides (NOx) |
Specific extinguishing methods | Use extinguishing measures that are appropriate to local circumstances and the surrounding environment.
|
Further information | Collect contaminated fire extinguishing water separately. This must not be discharged into drains. Fire residues and contaminated fire extinguishing water must be disposed of in accordance with local regulations.
|
Special protective equipment for firefighters
| Wear self-contained breathing apparatus for firefighting if necessary.
|
SECTION 6. ACCIDENTAL RELEASE MEASURES | |
---|---|
Personal precautions, protective equipment and emergency procedures | Material can create slippery conditions. Use non-slip safety shoes in areas where spills or leaks can occur. Refer to protective measures listed in sections 7 and 8. |
Environmental precautions | Prevent product from entering drains. Prevent further leakage or spillage if safe to do so. If the product contaminates rivers and lakes or drains, inform respective authorities. |
Methods and materials for containment and cleaning up | Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Keep in suitable, closed containers for disposal. |
SECTION 7. HANDLING AND STORAGE | |
Advice on safe handling
| For personal protection see section 8. Avoid contact with eyes. Smoking, eating and drinking should be prohibited in the application area. Dispose of rinse water in accordance with local and national regulations.
|
Conditions for safe storage | Keep container tightly closed in a dry and well-ventilated place. Containers which are opened must be carefully resealed and kept upright to prevent leakage. |
Materials to avoid | No materials to be especially mentioned. |
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | ||||
Components with workplace control parameters | ||||
Components | CAS-No. | Value type (Form of exposure) | Control parameters / Permissible concentration | Basis |
glycerol | 56-81-5 | TWA (mist, respirable fraction) | 5 mg/m3 | OSHA Z-1 |
|
| TWA (mist, total dust) | 15 mg/m3 | OSHA Z-1 |
|
| PEL (Mist - total fraction) | 10 mg/m3 | CAL PEL |
|
| PEL (Mist - respirable fraction) | 5 mg/m3 | CAL PEL |
|
| TWA (Mist - total dust) | 10 mg/m3 | OSHA P0 |
|
| TWA (Mist - respirable fraction) | 5 mg/m3 | OSHA P0 |
Engineering measures | effective ventilation in all processing areas | |||
Personal protective equipment | ||||
Respiratory protection | In case of insufficient ventilation, wear suitable respiratory equipment. | |||
Hand protection Remarks | No special protection is required. | |||
Eye protection | Eye protection is not required while washing with this product. In the workplace, the use of safety glasses is recommended to avoid eye exposure during the handling of containers or during spill clean-up. Remove respiratory and skin/eye protection only after vapours have been cleared from the area. | |||
Skin and body protection | No special protection is required. | |||
Hygiene measures | When using do not eat or drink. When using do not smoke. Wash hands before breaks and at the end of workday. |
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | ||
Appearance | viscous liquid | |
Colour | clear, red, orange | |
Odour | No data available | |
Odour Threshold | No data available | |
pH | 5 - 6 | |
Melting point/freezing point | No data available | |
Boiling point | 100 °C | |
Flash point | does not flash | |
Evaporation rate | No data available | |
Upper explosion limit | No data available | |
Lower explosion limit | No data available | |
Vapour pressure | No data available | |
Density | 1.015 g/cm3 | |
Solubility(ies) | ||
Water solubility | completely soluble | |
Partition coefficient: noctanol/water | No data available | |
Auto-ignition temperature | No data available | |
Viscosity, kinematic | No data available | |
:
|
SECTION 10. STABILITY AND REACTIVITY | |
---|---|
Reactivity | Stable |
Chemical stability | Stable under normal conditions |
Possibility of hazardous reactions | No decomposition if stored and applied as directed |
Conditions to avoid | No data available |
Incompatible materials | No data available |
Hazardous decomposition products | No decomposition if stored normally. |
SECTION 11. TOXICOLOGICAL INFORMATION | |
Potential Health Effects | |
Aggravated Medical Condition | :None known. |
Symptoms of Overexposure
| Effects are immediate and delayed. Symptoms may include irritation, redness, pain, and rash. Causes serious eye irritation. Review section 2 of SDS to see all potential hazards. Treat symptomatically. Symptoms may be delayed. |
Carcinogenicity | |
IARC | No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC. |
ACGIH | No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by ACGIH. |
OSHA | No component of this product present at levels greater than or equal to 0.1% is on OSHA’s list of regulated carcinogens. |
NTP
| No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated carcinogen by NTP. |
Acute oral toxicity | Acute toxicity estimate : 3,549 mg/kg Method: Calculation method |
Acute inhalation toxicity | Acute toxicity estimate : > 200 mg/l Exposure time: 4 h Test atmosphere: vapour Method: Calculation method |
Skin corrosion/irritation | Result: No skin irritation |
Serious eye damage/eye irritation | Remarks: Irritating to eyes. |
Respiratory or skin sensitisation | No data available |
Germ cell mutagenicity | No data available |
Carcinogenicity | No data available |
Reproductive toxicity | No data available |
STOT - single exposure | No data available |
STOT - repeated exposure | No data available |
Aspiration toxicity | No data available |
Further information | No data available |
SECTION 12. ECOLOGICAL INFORM | |
Ecotoxicity | No data available |
Persistence and degradability | No data available |
Bioaccumulative potential | |
Partition coefficient: noctanol/water | No data available |
glycerol : Partition coefficient: noctanol/water | log Pow: -1.76 |
Mobility in soil | No data available |
Other adverse effects | No data available |
Regulation | 40 CFR Protection of Environment; Part 82 Protection of Stratospheric Ozone - CAA Section 602 Class I Substances |
Remarks | This product neither contains, nor was manufactured with a Class I or Class II ODS as defined by the U.S. Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A + B). |
Additional ecological information | An environmental hazard cannot be excluded in the event of unprofessional handling or disposal., Harmful to aquatic life. |
SECTION 13. DISPOSAL CONSIDERATIONS | |
Disposal methods | |
Waste from residues | The product should not be allowed to enter drains, water courses or the soil. Do not contaminate ponds, waterways or ditches with chemical or used container. Dispose of in accordance with local regulations.
|
Contaminated packaging | Empty remaining contents. Dispose of as unused product. Do not re-use empty containers. |
SECTION 14. TRANSPORT INFORMATION | |
---|---|
Transportation Regulation: 49 CFR (USA): | NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL |
Transportation Regulation: IMDG (Vessel): | NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL |
Transportation Regulation: IATA (Cargo Air): | NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL |
Transportation Regulation: IATA (Passenger Air): | NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL |
Transportation Regulation: TDG (Canada): | NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL |
The product as delivered to the customer conforms to packaging requirements for shipment by road under US Department of Transportation (DOT) regulations. Additional transportation classifications noted above are for reference only, and not a certification or warranty of the suitability of the packaging for shipment under these alternative transport regulations. |
SECTION 15. REGULATORY INFORMATION
TSCA list : No substances are subject to a Significant New Use Rule.
No substances are subject to TSCA 12(b) export notification
requirements.
EPCRA - Emergency Planning and Community Right-to-Know Act CERCLA Reportable Quantity
This material does not contain any components with a CERCLA RQ.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
SARA 311/312 Hazards : Serious eye damage or eye irritation
SARA 302 : No chemicals in this material are subject to the reporting requirements of SARA Title III, Section 302.
SARA 313 : This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313.
California Prop. 65
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other reproductive harm.
The components of this product are reported in the following inventories:
DSL All components of this product are on the Canadian DSL
TSCA On TSCA Inventory
For information on the country notification status for other regions please contact the manufacturer’s regulatory group.
Inventory Acronym and Validity Area Legend:
TSCA (USA), DSL (Canada), NDSL (Canada)
SECTION 16. OTHER INFORMATION
Further information
NFPA:
HEALTH | 2 |
FLAMMABILITY | 0
|
INSTABILITY | 0 |
SPECIAL HAZARD. |
|
0 = not significant, 1 =Slight,
24 = Extreme = Moderate , 3 = High
HMIS III:
HEALTH | 2 |
FLAMMABILITY |
0
|
PHYSICAL HAZARD | 0 |
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
OSHA - GHS Label Information:
Hazard pictograms :
Exclamation mark | ||
Signal word | : | Warning: |
Hazard statements | : | Causes serious eye irritation. |
Precautionary statements | : |
Prevention: Wash skin thoroughly after handling. Wear eye protection/ face protection. Response: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/ attention. |
Version: | 1.2 |
Revision Date: | 04/24/2020 |
Print Date: | 07/15/2020 |
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind. The information in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. Users should make their own investigations to determine the suitability and applicability of the information for their particular purposes. This SDS has been prepared by the Compliance Services organization supporting this manufacturer, supplier or distributor.